Lake County Health Department and Community Health Center
500 West Winchester Road Suite 102
Libertyville, IL 60048
Establishment
OSAKA MUNDELEIN
License/Permit #
002115
Street Address
1452 S BUTTERFIELD RD
City/State
MUNDELEIN, IL
ZIP Code
60060
No. of Risk Factor/Intervention Violations
1
No. of Repeat Risk Factor/Intervention Violations
0
Date
07/27/2023
Time In
11:00 AM
Time Out
12:20 PM
Permit Holder/Person Interviewed/Person In Charge (PIC) RYAN CHOI
Risk Category High
Purpose of Inspection Routine
FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance OUT=not in compliance N/O=not observed N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection R=repeat violation
Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury.
Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
COS
R
SUPERVISION
1
IN
OUT
Person in charge present, demonstrates knowledge, and performs duties
2
IN
OUT
N/A
Certified Food Protection Manager
EMPLOYEE HEALTH
3
IN
OUT
Management, food employee and conditional employee; knowledge, responsibilities and reporting
4
IN
OUT
Proper use of restriction and exclusion
5
IN
OUT
Procedures for responding to vomiting and diarrheal events
GOOD HYGIENIC PRACTICES
6
IN
OUT
N/O
Proper eating, tasting, drinking, or tobacco use
7
IN
OUT
N/O
No discharge from eyes, nose, and mouth
PREVENTING CONTAMINATION BY HANDS
8
IN
OUT
N/O
Hands clean & properly washed
9
IN
OUT
N/A
N/O
No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed
10
IN
OUT
Adequate handwashing sinks properly supplied and accessible
APPROVED SOURCE
11
IN
OUT
Food obtained from approved source
12
IN
OUT
N/A
N/O
Food received at proper temperature
13
IN
OUT
Food in good condition, safe, & unadulterated
14
IN
OUT
N/A
N/O
Required records available: shellstock tags, parasite destruction
Compliance Status
COS
R
PROTECTION FROM CONTAMINATION
15
IN
OUT
N/A
N/O
Food separated and protected
16
IN
OUT
N/A
Food-contact surfaces: cleaned & sanitized
17
IN
OUT
Proper disposition of returned, previously served, reconditioned & unsafe food
TIME/TEMPERATURE CONTROL FOR SAFETY
18
IN
OUT
N/A
N/O
Proper cooking time & temperatures
19
IN
OUT
N/A
N/O
Proper reheating procedures for hot holding
20
IN
OUT
N/A
N/O
Proper cooling time and temperature
21
IN
OUT
N/A
N/O
Proper hot holding temperatures
22
IN
OUT
N/A
N/O
Proper cold holding temperatures
23
IN
OUT
N/A
N/O
Proper date marking and disposition
24
IN
OUT
N/A
N/O
Time as a Public Health Control; procedures & records
CONSUMER ADVISORY
25
IN
OUT
N/A
Consumer advisory provided for raw/undercooked food
HIGHLY SUSCEPTIBLE POPULATIONS
26
IN
OUT
N/A
Pasteurized foods used; prohibited foods not offered
FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES
27
IN
OUT
N/A
Food additives: approved and properly used
28
IN
OUT
N/A
Toxic substances properly identified, stored, & used
X
CONFORMANCE WITH APPROVED PROCEDURES
29
IN
OUT
N/A
Compliance with variance/specialized process/HACCP
GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R
COS
=corrected on site during inspection
R
=repeat violation
Compliance Status
COS
R
SAFE FOOD AND WATER
30
Pasteurized eggs used where required
31
Water & ice from approved source
32
Variance obtained for specialized processing methods
FOOD TEMPERATURE CONTROL
33
Proper cooling methods used; adequate equipment for temperature control
34
Plant food properly cooked for hot holding
35
Approved thawing methods used
36
Thermometers provided & accurate
FOOD IDENTIFICATION
37
Food properly labeled; original container
PREVENTION OF FOOD CONTAMINATION
38
X
Insects, rodents, & animals not present
39
Contamination prevented during food preparation, storage & display
Adequate ventilation & lighting; designated areas used
EMPLOYEE TRAINING
57
X
All food employees have food handler training
X
58
Allergen training as required
IOCI 17-356
Food Establishment Inspection Report
Page
2
of
??????
Establishment: OSAKA MUNDELEIN
License/Permit #: 002115
Date: 07/27/2023
Water Supply:
Community
Non-Community
Licensed Non-Community
Waste Water System:
Community
On-Site
IEPA System
Sanitizer:
Temperature Logs in Use:
Location
Method
Sanitizer Type
Concentration (PPM)
Heat(F)
HT Dish Machine
Hot Water
Hot Water
0
170.00
Wiping Cloth Bucket
Chemical Sanitizer
Chlorine
100
0.00
CFPM Verification (name, expiration date, ID#):
RYAN CHOI 08/22/2026 20926685
Presentation Type:
DEMONSTRATION
Number Attended:
3
HACCP Discussed
HACCP Principle
Plan Onsite
3. Establish the Critical Limit for the CCP
Discussed the HACCP principle of identifying critical control points in your processes such as hot holding at 135 degrees F or above, cold holding at 41 degrees F or below and at freezing for frozen foods and 165 degrees F for reheating.
No
TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
CHICKEN/REACH-IN COOLER
39.00°F
TUNA/SUSHI DISPLAY COOLER
36.00°F
TUNA/WALK-IN COOLER
41.00°F
NOODLES/CHEST FREEZER
0.00°F
FISH/ONE-DOOR UPRIGHT FREEZER
0.00°F
RICE/RICE WARMER
169.00°F
OBSERVATIONS AND CORRECTIVE ACTIONS
P=Priority PF=Priority Foundation C=Core R=Repeat
Item Number
P/PF/C/R
Code Reference
Violations cited in this report must be corrected within the time frames below.
28
PF
7-202.11
(A) Only those POISONOUS OR TOXIC MATERIALS that are required for the operation and maintenance of a FOOD ESTABLISHMENT, such as for the cleaning and SANITIZING of EQUIPMENT and UTENSILS and the control of insects and rodents, shall be allowed in a FOOD ESTABLISHMENT. A can of RAID and fly insect spray was found in the facility. Remove the item immediately.
CORRECTED
38
PF
6-501.111 (C)
The PREMISES shall be maintained free of insects, rodents, and other pests. The presence of insects, rodents, and other pests shall be controlled to eliminate their presence on the PREMISES by: (C) Using methods, if pests are found, such as trapping devices or other means of pest control.
Roaches observed, live, in the kitchen, under the reach-in cooler. Eliminate pests, using proper pest control processes as needed.
CORRECT BY: Aug 4, 2023
55
C
6-501.12
(A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing. The floor under the reach-in cooler and cooking area is soiled. Routinely clean all floors, mats and duckboard.
CORRECT BY NEXT ROUTINE INSPECTION
55
C
6-501.12
(A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing. The walls in kitchen, adjacent to the hood and the hood is soiled. Routinely clean all walls, ceilings and attached equipment.
CORRECT BY NEXT ROUTINE INSPECTION
57
C, R
750.3400 (a)
a) All food handlers, other than someone holding a food service sanitation manager certificate, shall receive or obtain training in basic food handling principles, within 30 days after employment.
All food handlers have not been trained. All food handlers must be trained by the next routine inspection.
Repeat,CORRECT BY NEXT ROUTINE INSPECTION
RYAN CHOI Person In Charge (Signature)
David Groh Inspector
Follow-up:
Yes
No
Follow-up Date:
08/04/2023
This was a routine inspection. Because there were certain violations cited, a re-inspection is required.
If these violations are not corrected at the time of the re-inspection, an additional re-inspection will be required, and a re-inspection fee of $328.00 will be assessed per the Lake County Code Chapter 173.
I (the facility Owner/Manager) have read and acknowledge the statement checked above.
